Product ID:215S CHROMATE PRIMER
MSDS Date:01/01/1987
FSC:8010
NIIN:00N008118
MSDS Number: BCPLL

DU PONT E I DE NEMOURS & CO FABRICATED PROD DEPT

1007 MARKET ST BRANDYWINE BLDG 3332
WILMINGTON, DE 19898
US

Emergency Phone: 800-441-3637

Info Phone: 302-999-3847 OR 302-999-4338

Cage: 90227

DU PONT E I DE NEMOURS & CO FABRICATED PROD DEPT

WILMINGTON, DE 19898 US

Telephone: 800-441-3637

Cage: 90227

ACETONE (SARA III)

CAS: 67-64-1

RTECS: AL3150000

OSHA PEL 1000PPM

ACGIH TLV: 750PPM/1000STEL;9293

EPA Report Quantity: 5000 LBS

DOT Report Quantity: 5000 LBS

METHYL ETHYL KETONE (2-BUTANONE) (MEK) (SARA III)

CAS: 78-93-3

RTECS: EL6475000

OSHA PEL 200 PPM/300 STEL

ACGIH TLV: 200 PPM/300STEL 9192

EPA Report Quantity: 5000 LBS

DOT Report Quantity: 5000 LBS

ACRYLIC RESIN

CAS: 9003-01-4

RTECS: AT4680000

ZINC CHROMATE

CAS: 13530-65-9

RTECS: GB3290000

OSHA PEL 0.1 MG/M3 (CRO3)

ACGIH TLV: 0.01MG/M3(CR)A1;9192

Effects of Overexposure:INGEST:GI DISTRESS.INHAL:POSS NOSE&THROAT
IRRIT.POSS NERVOUS SYS DEPRESSION CHARAC BY:(SEE SUPP DATA

First Aid:INGEST:CALL PHYS IMMED,HAVE INGREDIENT NAMES AVAIL. INHAL:OF
VAP/SPRAY MIST,REMOVE TO FRESH AIR.IF BREATHING DIFFICULTY
PERSISTS/OCCURS LATER,CALL PHYS. EYE:IMMED FLUSH W/PLENTY H*2O @
LEAST 15 MIN;CA LL PHYS.SKIN:WASH W/SOAP&H*2O;IRRIT OCCURS,CALL MD

Flash Point:20-73F,-7-23C;CC
Lower Limits:1.1%
Upper Limits:14%
Extinguishing Media:FOAM,CARBON DIOXIDE,DRY CHEMICAL
Fire Fighting Procedures:RECM FULL PROTECTIVE EQUIP W/SCBA.MAY USE
H*2O(SEE OTHR PREC
Unusual Fire/Explosion Hazard:WHEN HEAT ABOVE FLASH PT,EMITS FLAMM
VAPORS WHICH,WHEN MIX W/AIR,CAN BURN/BE EXPLOSIV.(SEE OTHR PREC

Spill Release Procedures:VENTILATE AREA. REMOVE SOURCES OF IGNITION.
PREVENT SKIN CONTACT & BREATHING OF VAPOR. CONFINE & REMOVE W/INERT
ABSORBANT.

Handling and Storage Precautions:OBSERVE LABEL PRECAUTNS.KEEP FROM
HEAT,SPARKS,FLAME.CLOSE CNTNR AFT USE.GROUND CNTNRS WHEN POUR.WASH
AFT HANDLE,BEFORE EAT/SMOKE.DONT STORE ABOVE 120F
Other Precautions:USE NIOSH/MSHA APVD RESPIRATR/PROPR VENT WHEN
SAND.FLAME CUT,BRAZE,WELD DRY COATING.FIRE FIGHT:TO COOL CLOSED
CNTNRS TO PREV PRESS BLDUP.FIRE,EXPLO:FINE MIST/SPRAY POSS FLAMM
@TEMPS

Respiratory Protection:NIOSH/MSHA TC-23C APVD PAINT SPRAY RSPTR IF
APPLY&UNTIL EXHAUST VAPS
Ventilation:SUFFICIENT IN VOLUME&PATTERN TO KEEP CONTAM REQUIRMNTS
Protective Gloves:NEOPRENE GLOVES
Eye Protection:W/SPLASH GUARDS/SIDESHLDS
Other Protective Equipment:COVERALLS RECOMMENDED
Supplemental Safety and Health
HEADACHE,DIZZ,NAUS,STAGGER,CONFUSN,UNCONSCIOUS.HIGH CONC MEK-EMBRYOTOX
IN LAB ANIMALS.PRLNG/RPTD SOLVNT OVEREXP-PERM BRAIN&NERV SYS
DAMAGE.EYE:IRRIT/BURN.SKIN:PRLNG/RPTD CONT-IRRIT,DERMATITIS.

HCC:F3
Boiling Pt:B.P. Text:129F-401F
Vapor Density:>1
Evaporation Rate & Reference:SLOWER THAN ETHER
Solubility in Water:SLIGHT
Appearance and Odor:DENSITY:6.8-12.7 #/GALLON

Stability Indicator/Materials to Avoid:YES
NONE REASONABLY FORESEEABLE
Hazardous Decomposition Products:CO,CO*2,SMOKE,OSIDES OF ZINC &
CHROMIUM

Waste Disposal Methods:DO NOT ALLOW MATERIAL TO CONTAMINATE GROUND
WATER SYSTEMS. INCINERATE ABSORBED MATERIAL IN ACCORDANCE
W/FEDERAL,STATE & LOCAL REQUIREMENTS. DO NOT INCINERATE IN CLOSED
CONTAINERS.

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.